door seal rain leak
-
- Registered User
- Posts: 885
- Joined: Sat Jun 18, 2011 9:48 am
door seal rain leak
my headliner is soaked right around the top of the door on the driver side. its not the foam that goes all the way around the one that just goes along the top of the door that i think is the culprit. i pulled it off and it has a badly rotted clear silicone bead. i'm going to go ahead and redo that but what else should i look at in that area? the headliner is wet from the door jamb area to the sun visor....
- 3X00-Modified
- Administrator
- Posts: 10912
- Joined: Thu Jul 05, 2007 9:18 am
- Location: Brooklyn CT
-
- Registered User
- Posts: 885
- Joined: Sat Jun 18, 2011 9:48 am
- 3X00-Modified
- Administrator
- Posts: 10912
- Joined: Thu Jul 05, 2007 9:18 am
- Location: Brooklyn CT
Re: door seal rain leak
Take the hinge off, drill it out bush it and replace it with a removable pin... But if you have a rusty roof around the seal then that's a different problem.
-
- Registered User
- Posts: 885
- Joined: Sat Jun 18, 2011 9:48 am
Re: door seal rain leak
man this the JFK magic bullet/WTC7 collapse of water leaks! the headliner is wet from the visor to rear of the door. silicone was no joy stop it and the door appears to be closing correctly. here's the kicker though, there is zero water on the windshield and the water on the dash is closer to the windshield than the steering wheel area. almost as if its being projected from under the headliner. i have dash mat that is water resistant so it just beads up whatever water gets on it. i need a water leak commission to some investigating......
- 3X00-Modified
- Administrator
- Posts: 10912
- Joined: Thu Jul 05, 2007 9:18 am
- Location: Brooklyn CT
Re: door seal rain leak
Sounds like the front of the roof under the windshield is leaking... Remove your headliner and see where the drips come from.
-
- Registered User
- Posts: 885
- Joined: Sat Jun 18, 2011 9:48 am
Re: door seal rain leak
i pulled it down on that side yesterday and there was condensation/moisture all the way to the door jamb from the front. i'm baffled to say the least.......
- 3X00-Modified
- Administrator
- Posts: 10912
- Joined: Thu Jul 05, 2007 9:18 am
- Location: Brooklyn CT
Re: door seal rain leak
Then its leaking from the windshield... the condensation you see could be pollution from the headliner soaking up the water, hence why you need to remove the whole headliner and wait till it leaks again and see where it drips from. As long as you have something there to soak it up its going to spread and leave you clueless as to where the water is coming in.